Tuesday, March 30, 2010

End of the Regionals?

In the airline industry, the last ten years could well be known as "The Decade of Regional Airlines." To be sure, they had been around for many years prior. The 1960s and 1970s saw the beginnings of the industry, the 1980s bore airline proliferation, air service agreements, and express branding, and the 1990s witnessed the introduction of the regional jet and the fee-per-departure model still prevalent today. All this was mere prelude to the decade between 2000 and 2010, when the regional airline industry underwent explosive growth that surpassed even the vaunted low-cost carriers. Regional airline traffic doubled over this period, to the point that they now account for 53% of all U.S. departures. Regional airline capacity increased even more, with larger aircraft driving a 178% increase in available seat miles (ASMs).

This expansion is all the more startling when one compares it to the retreat of the legacy carriers, who shrunk from 534 billion domestic ASMs in 2000 to 408B ASMs in 2009. Even when you add in the burgeoning LCC sector, mainline capacity has decreased slightly. Financially, the regional airlines have been consistently profitable in a period that saw the legacy carriers lose money six out of nine years, for a net loss of over $63,000,000,000. Ironically, regional airlines flush with profits have proven a ready source of lending for their cash-strapped major airline partners. This occasionally results in tail-wagging-the-dog situations, such as Republic Airways Holdings' purchase of its customer and debtor, Midwest Airlines, and subsequent replacement of all Midwest aircraft and employees with those of Republic Airlines. Republic even had enough money left over to pick up ailing Frontier Airlines thanks to tony contracts with American, Continental, Delta, United, and USAirways - all ostensibly competitors of Frontier.

By its very success, however, the regional airline industry may have sown the seeds of its destruction. Barring one exceptional contingency I'll discuss later, it is quite possible that the coming decade will see not only an end to regional airline growth but perhaps also a steep decline in regional airline capacity and a winnowing of the existing carriers.

Most of the growth in the 37-50 seat regional jet segment prior to 9/11 was replacement of existing 29-38 seat turboprop service. Most of these short-haul flights were used primarily to feed transcontinental and international service, the most profitable flying for most legacy airlines. These high-value customers strongly preferred jets to turboprops, and in the era of cheap fuel it seemed like replacing turboprop aircraft with regional jets would give a carrier a strong advantage. Most major airline pilot scope clauses allowed a only limited number of regional jets to be outsourced prior to 9/11, although there were a few exceptions: WidgetCo, for example, ordered hundreds of CRJ-100s and CRJ-200s in the mid to late 1990s.

After 9/11, the legacy airlines aggressively cut capacity in a vain attempt to boost yields (it was all for naught because expanding LCCs aggressively filled the void). These capacity cuts were achieved both by reducing frequencies between city pairs and downgauging equipment. In the case of routes flown by the smallest narrowbodies like DC-9s, B737-200s, and Fokker 100s, the next smallest equipment that could be used were CRJ-200s. All the legacies obtained much looser scope limits on 50-seat RJs as part of the post-9/11 concessions, and a number of regional airlines exploded in growth as the majors retired their aging small narrowbody fleets.

The problem was that even when fuel was cheap and yields high, 50-seat RJs were marginally profitable airplanes at best; remember, they were only intended to feed more lucrative flying. They were poorly suited to replace mainline jets twice their size on major routes, particularly as fuel became more expensive and yields stayed depressed. Bombardier and Embraer responded by developing 70-90 seat jets. The post-9/11 scope clauses allowed only limited numbers of these airplanes, but the 2003-2005 round of airline bankruptcies gutted these clauses and the airlines ordered large numbers of these big RJs. Most of these went to regional airlines; only a few 90-100 seat jets were ordered at mainline carriers (USAirways and jetBlue). It was this two-part wave of 50 seat and 70-90 seat outsourcing that allowed nearly continuous growth at the regional airlines throughout the last decade.

This growth, however, has now all but stopped, and in several cases reversed. All of the major airlines are at or near the limits on outsourced large RJs allowed under scope clauses, and few pilot groups seem inclined to make further concessions on scope (one group, the American Airlines pilots, are demanding that all jet flying be returned to mainline). Meanwhile, the 50-seat RJs are starting to get long in the tooth and are proving both overly expensive to operate and unpopular on long routes. Many airlines are aggressively cutting 50-seaters as their air service contracts expire (or, in the case of wholly-owned regional airlines, retiring 50-seaters as the leases expire). Some regional airlines have managed to replace expiring 50-seat flying with new 70-90 seat flying, making mere stagnation the best-case scenario over the last two years. Others have been unable to do so due to high costs (Air Wisconsin, Comair, ExpressJet) or a record of poor service (Mesa), resulting in significant shrinkage at those airlines.

The plight of Mesa is a good example of the challenges posed by this shrinkage. Throughout the 1990s and early 2000s, Mesa grew from a small turboprop airline flying EAS routes to an absolute giant of the industry flying everything from B1900s to 88-seat CRJ-900s for airlines including American West, USAirways, United, Delta, Midwest, and Frontier. They did this by aggressively underbidding other regional airlines whenever major airlines put out an RFP. The rapid expansion kept crew and maintenance costs low, as did the company's notorious emphasis on low overhead and minimal infrastructure. The airline got a reputation for poor service early on, but this did not slow its growth as long as it was the cheapest option. Once there were few new contracts to bid for, however, Mesa's costs rapidly grew to parity with other regional carriers, resulting in an absolute dearth of new flying and existing contracts being allowed to expire. Desperate to keep these sidelined aircraft flying, Mesa entered the cutthroat Hawaiian inter-island market by starting go! Airlines. Like ACA and ExpressJet before it, Mesa discovered than making money as an independent airline while flying regional aircraft is a very tough proposition. The venture continued to lose money even after a vicious fare war started by Mesa resulted in Aloha Airlines' demise. Ultimately, Mesa Air Group filed for bankruptcy in January of this year. They are proposing to return half from their current fleet of 136 planes to their lessors; in 2006 they had 216 airframes. Their future business plan is unclear, as there are few costs they can cut in bankruptcy aside from rejecting unused aircraft leases, and it seems unlikely there will be new major airline contracts up for bid anytime soon.

Regional airline CEOs must look upon Mesa's fate with horror. Mesa went from being the 800 lb gorilla of the industry to near extinction in four short years. All it took was a slight maturation to set off a viscous cycle of increased costs and reduced flying - and this is a prospect every regional airline faces. The only reason major airlines ever chose to outsource small jet flying rather than do it themselves was because the regionals had such a cost advantage, even after duplicating infrastructure and management and taking their guaranteed profit. That cost advantage no longer exists; not only are the regionals getting much more expensive as their fleets age and employee longevity increases, but the mainline carriers' own costs are far, far lower in the post-bankruptcy era than they were at the height of the outsourcing craze. Meanwhile, increased government and media scrutiny of regional airlines in the wake of the Colgan crash have made outsourcing less palatable than it once was.

Most current air service agreements expire between 2013 and 2018. It is seeming likelier that this will occur in a period of economic growth, when mainline carriers are upgauging service, potentially making the 50-seat contracts even less likely for renewal. As regional carriers shed 50 seaters, their 70-90 seat costs will increase significantly. As these contacts come up for renewal, existing regional airlines will not only be competing with other regionals for the flying but likely against mainline itself, as well as the possibility of mainline forming brand new wholly-owned carriers to perform the flying a la NewCo. Many airlines will face the unsavory choice between signing contracts for flying below cost and shrinking into oblivion. One suspects that this is the scenario that Republic management was thinking of when it made the otherwise inscrutable move of snapping up not one but two national airlines that directly compete with its erstwhile mainline partners.

I think the regional airline industry will always be around in some form, as there will always be some role for 50-seat RJs as well as small turboprops, and the chances of mainline pilots expending the negotiating capital necessary to recapture all currently outsourced flying seem rather remote to me. I do think, however, that the industry will look drastically different 10 years from now.

I did mention that there is one contingency that would avoid the "doomsday scenario" laid out above. That is if mainline pilots give up 100-seat scope in the next round of contract negotiations, presumably for some restoration of pay and benefits. If this happened, you would see the wholesale replacement of MD80, B737, and A320 mainline flying with outsourced next-generation aircraft like the forthcoming C-Series. This would help offset the 50-seat retirements and give many regional carriers a new lease on life. It would, however, result in the loss of thousands of mainline pilot jobs, and mainline pilots will have rendered themselves irrelevant and exposed to other schemes such as the outsourcing of widebody international flying, an early example of which is United's joint venture with Aer Lingus. I find it difficult to imagine mainline groups hoisting themselves by their own petard in such a manner, but it's happened before.

14 comments:

Colin said...

I believe we are also seeing an example of empire building, where it is always easy to continue as long as the empire is expanding. KEEPING the empire any particular size is a different problem, and a very difficult one.

Sam Weigel said...

Good analogy. You could make the argument for parallels between Republic's purchase of YX and F9 and the Athenians' invasion of Syracuse even as their Aegean empire was being lost to the Spartans, or any other examples throughout history of empires doing reckless things when the status quo is unpalatable.

Craig said...

Nice analysis and short history on the rise of the regionals, Sam.
All of us flying RJ's at least most of us) hope that the majors do not give up more scope. Enough damage has been done. We're starting to see the latest effects of it now. Republic flying a 100 seat plane for 70 seat rates is helping to demolish the narrow body pilot standard of living as we watch. As long as there are pilots willing to fly for substandard wages, and pilots are the top willing to give up scope, we will still have whipsawing and a degredation of this career.

Anonymous said...

That's a very thorough and vivid depiction of the aviation industry as it stands today, and applause for that. Things are really at the breaking point, and some change is sure to follow. Stewardesses working as part-time prostitues? How degrading to the profession is that! A manager at a TacoBell easily makes more than a pilot in the first few years of slaughtering work! Unless Congress decides to listen, we will have to make them listen to us! Once again, bravo to the analysis.

typingtalker said...

When RJs first entered service, one analyst predicted failure saying that they were suited for long thin routes not the short feeder routes where they were being deployed. It took a long time but the airlines are finally agreeing.

Rafael from iloveplanes.com said...

I think every industry has to have a shake out every once in a while. Do you think that what's happening now is a shake out of the regionals that lost sight of the fundamentals?

Nick said...

I mean this in with the utmost respect but you are very negative in all of your posts and you never seem to be able to find the good in this career anymore. I enjoyed your blog and reading about your life as a pilot but I am now becoming tired of reading your pessimistic outlook on this profession. Can you not find anything good about doing what you love? I know the economy sucks right now but this happens. It goes in swings and it will be booming in the future. I guess I just miss reading about your job and I am tired of hearing how awful it is and how the industry is headed for the dumps.

Anonymous said...

Ditto Nick!
Bill

Anonymous said...

I don't believe that the blog is overly negative it is just a reflection of reality.

2whls3spds said...

@Nick

He is posting the truth as he sees it. There is not much rosy at all in the current airline industry, whether it be mainline or regional.

IMHO there are two ways to look at it, you can look at the facts good or bad and state them, which Sam does. Or you can take the Jiminey Cricket philosophy that everything is just rosy and get caught when it really isn't.

There are so many undetermined variables at the moment that anyone who thinks they can predict the future of the economy and any given business is a fool. From my observations the ones in charge are doing one thing and one thing only they are managing to maximize lining their pockets and not much more, it happening in most if not all industries at this point.

Aaron

Anonymous said...

Nick -

You may have actually missed the whole point on this one.

This blog entry IS a positive one!!

The end of the regionals is about as positive as it gets, from safety to careers to passenger comfort. They need to die and never come back again. If not, they need to shrink as much as possible.

Growth of the mainline carriers is positive. Read the blog entry again with this in mind!

FlyCRJ said...

I don't think either are going away anytime soon. Like the old saying goes, "the more things change, the more they remain the same." What is going on now is no different than what has gone on in the past...it just looks different.

The focus of the pilot should be to decide if it a career you want to be involved in. Like any industry, you are never "safe" and aviation is as turbulent as any job out there. But, if it is a career you want to go into, then go and do it.

Just have a backup plan and always have one foot out the door.

Regards,

Jeffrey

Unknown said...

Hi Sam,

Can you sen me your e-mail? I'm a writer for a trade publication, and am trying to write something on consolidation and regionals. I'm at oconnellmedia@yahoo.ca.

Hope to hear from you!

Denise

typingtalker said...

Article from Air Transport World, Has the Regional Bubble Burst?

http://atwonline.com/aeropolitics-regulation/article/has-regional-bubble-burst-0511?utm_source=feedburner&utm_medium=feed&utm_campaign=Feed%3A+AtwDailyNews+%28ATW+Daily+News%29